Versions Compared

Old Version 28

changes.mady.by.user Aidan Bowers

Saved on

compared with

New Version Current

changes.mady.by.user Daniel Puratich

Saved on

Key

  • This line was added.
  • This line was removed.
  • Formatting was changed.
Table of Contents

...

Name

Role

@Hardy Yu (maybe)

flight test coordinator

Aidan Bowers (Deactivated)

providing vehicle and insight

Hardy Yu

Aidan Bowers (Deactivated)

Daniel Puratich

Joe

📊 Success criteria

Tests

Success Criteria

Requirements

Outcome

Range Test

  • No failsafe/link loss from flying houston at opposite ends of the WRESTRC training grounds

  • RFD900x should be tested and ready to fly on Houston before flying

  • RFD worked to 500 meters during minor test

PPM Passthrough

⏲️ Testing Timeline

Date/Time

Action

Aircraft Assembly

Houston should be ready to go with the RFD900x as well as with any relevant hardware for testing ZP

9pm

Pre-flight Preparation

  • Ensure checklists for Houston

  • Ensure all items in checklist are followed

9am

Flight brief from flight test lead

10am

Loading onto the Car

Take your water bottle with you. Go washroom before we leave!

10am

Drive to the test ground

10am-2pm

Flight Testing

2:15pm

Debrief

🧯 Aircraft Incident Procedures

Incident

Procedure

Crash

Outline the procedure for who will go to handle the aircraft in the event of a crash, what should be done, were emergency equipment is, etc.

Flyaway

Outline the procedure for flyaways. List relevant contact information for local authorities and plans of action to recover control of the aircraft

Configuration Error

Outline steps to take in the event of a configuration issue with the aircraft

Injury

Property Damage

🔧 Week-Before To-Do List

...

Item

Owner

  •  Use Flight-Post Mortem to Debrief

ALL MEMBERS PRESENTAidan Bowers (Deactivated) Daniel Puratich

  •  Discard of damaged batteries

N/A

  •  Discharge used batteries for better longevity to storage voltage

Hamza Ali

Flight Test Post Mortem

Tip

  • Autopilot was swag

  • All systems functioned well (RTL, Land, etc)

  • Our RFD900x worked well

  • Battery lasted a long time (at least 8 minutes, exact time tbd)

  • Failsafe (Lost link) went to RTL

  • Roughly 600m range tested (though we had historically done a 3km test)

  • Nobody got hurt (physically or mentally)

Note

  • No preflight briefing

    • We did not know what the success criteria was when we got there

    • Should take place right in the morning but did not happen

  • We weren't rigorous in our testing methodology

  • It was difficult to view the ground-station due to glare and short USB-cable to antenna tower

  • Key to WRESTRC was forgotten and we had to go back

  • No safety briefing

    • No safety captain was designated

  • Roles were not well defined

  • Timelines were not followed

    • and they were incorrect

  • Flight Controller configuration was not complete by the day before

  • Nothing was conformal coated

  • Houston was not registered and PIC phone number was not on the aircraft

  • Trusting the autopilot too much

    • not paying attention to the aircraft when near ground/people

  • No fire extinguisher

  • We messed up prop directions initially

  • The battery test was not added to the list of things to test

  • The entire premise of doing this RFD range test was misfounded

    • We had previously tested the RFD to 3km with worse antennas so the entire point of this range test was pointless

    • Last Cornflakes (Frostedflakes) flight test had an RTL (Return to land)

      • though this occurred when it wasn’t flying…

  • ZeroPilot PPM didn’t get tested

    • We wanted to test this but it wasn’t done in time

  • We didn’t drain a full battery

    • So we did not test battery life

    • This was another goal of the flight test that wasn’t listed

      • goals that aren’t listed we need to be careful on …

  • Flight plan to be decided before the day for sure

  • No media was obtained

    • We didn’t designate anyone to record or take photos and we ended with no media

    • We need to plan this

  • Props were scraped in a minor crash before the major one

    • We were skipping around on the ground and scraped all the props into the ground

,
Warning

  • We crashed into snow and there was no liquid protection

    • Including RCA for crash

    • We did not know what to do when the crash occurred

  • Flight test didn’t validate anything

    • This flight test cost us a ton of money and didn’t validate anything

      • We didn’t test the ZP PPM

      • We didn’t test range (which was already tested)

    • Clearer flight test plan should have been done in advance

      • We made out 2km test waypoint mission on the spot

RCA for Red Items

Create a RCA and keep it as a child page.

...

Child pages (Children Display)

Action Items

Hamza Ali Discharge batteries

Hamza Ali Interpret logs of flight test (Try to get some battery life metrics ??)

Wait for all electronics to dry out for a while

After drying we need to validate hardware and reassemble it

Put things away

Upload media to media ingest folder

Other Resources

Booking WRESTRC Field

How to Book the Flight Grounds